Some points we should pay attention to in the maintenance of cube ice machine

Some points we should pay attention to in the maintenance of cube ice machine


After we buy the ice machine, we must pay attention to the use and maintenance during daily maintenance and use, so as to prolong the service life of the ice machine.

The following are a few things we should pay attention to during the maintenance of the ice machine

1. When the ice machine is not working, please check whether the power supply is normal.

2. After the ice machine is installed, the customer needs to observe the operation of the machine regularly or irregularly, such as whether the water supply and power supply of the ice machine are normal, whether the compressor starts abnormally, and whether the ice-making effect meets the standard.

3. The ice machine needs a good operating environment under normal operation. Generally, a poor operating environment will cause failures such as: the ice-making effect is reduced, the life of the machine is shortened, and various protection systems are activated.

4. Before operating the machine, the operator must confirm that: the power supply, water source, have been connected and then start to work. If it is found that the machine cannot be started or the compressor does not respond to start, please check whether there is a phase loss in the power supply voltage, or the power supply voltage is too low.

5. Check whether the falling ice cubes are balanced under the normal operation of the machine. If the ice cubes are found to be too pure, or have high transparency. Treatment: properly adjust the regulator of the brine pump.

6. The brine tank must be cleaned regularly, at least once a month, to prevent non-condensable substances from depositing at the bottom of the tank

7. The operator should clean the ice machine regularly so that the ice machine can have a good working environment and operate in the best working condition. Cleaning objects Condenser, evaporator, water supply tank and some dirty and corrosive substances on the side of the machine.

8. Ice bucket failure confirmation: When the ice machine is working normally, is there any excessive noise in the ice bucket, and whether the falling ice looks like small pieces of ice.

9. Precautions: When shoveling ice, you must not shovel ice in the direction of the top to prevent the infrared protection device of the ice bucket from being shoveled and its system protection action cannot work normally. Correct method of shoveling ice: Ice shovel downwards upwards, or horizontally, do not shovel down to the top of the freezer